Catalytic Converter Catalytic Converter Catalytic Converter


home
about us
converter design
converter faq
converter failure
converter care
nox emissions
aftermarket converter
converter obd II
converter us law
converter links
converter news
converter replacement
site index
contact us

Discount Catalytic Converter
Catalytic Converter

Please support our site's generous sponsors.

Catalytic Converter
dot org
Contact Us

 
 
Catalytic Converter

Technical Service Bulletin 2001 - 2003 Toyota Sienna Van

October 19, 2005

Title: Technical Service Bulletin from Toyota

M.I.L. "ON" DTC P0420


Models:

2001 - 2003 Sienna Van

Introduction

Under certain driving conditions, some 2001 - 2003 model year Sienna vehicles may exhibit a M.I.L. "ON" with the following DTC:

P0420 (Catalyst System Efficiency Below Threshold [Bank 1])

The Engine Control Module (ECM) (SAE term: Powertrain Control Module/PCM) logic has been modified to improve this condition. Applicable Vehicles

2001 - 2003 model year Sienna vehicles.

   

Warranty Information

Applicable Warranty:

This repair is covered under the Toyota Federal Emissions Warranty. This warranty is in effect for 96 months or 80,000 miles, whichever occurs first, from the vehicle's in-service date.

* Warranty application is limited to correction of a problem based upon a customer's specific complaint.

Repair Procedure
1.     Verify DTC P0420 with the Diagnostic Tester by referring to the Technical Information System (TIS), 2001 - 2003 model year Sienna Repair Manual: Diagnostics: Engine: Pre-Check.

2.     Replace ECM (PCM). Follow the Repair Manual ECM replacement instructions. Refer to TIS, 2001 - 2003 model year Sienna Repair Manual: Introduction: How To Troubleshoot ECU Controlled Systems: How To Use The Diagnostic Chart And Inspection Procedure.

3.     Perform the following steps to confirm that the vehicle is repaired.

A.     Reset the Readiness test by using the "Clear DTC" function on the Diagnostic Tester.

         To clear the DTC, refer to TIS, 2001 - 2003 model year Sienna Repair Manual: Diagnostics: Engine: Pre-Check.

B.     Perform Readiness Monitor Drive Patterns for Catalyst Monitor 02S type and AF Sensor type. Refer to TSB No. EG003-02, "Readiness Monitor Drive Patterns," procedures: Catalyst Monitor (02S Type) and Catalyst Monitor (AF Sensor Type).

C.     If a DTC is set during the above drive patterns, refer to the Diagnostic Trouble Code Chart in TIS, 2001 - 2003 model year Sienna Repair Manual: Diagnostics: Engine: Diagnostic Trouble Code Chart. Test drive the vehicle to confirm normal operation.

4.     If NO DTCs (pending or current) are stored, the repair is complete.

 


 
 

home | catalytic converter care | about us | e-mail

ImageBuilders Web DesignCopyright 2004 ImageBuilders Web Design

 


Catalytic Converter Warehouse
Catalytic Converter

Please support our site's generous sponsors.


Catalytic Converter
Catalytic Converters dramatically reduce harmful exhaust emissions


Catalytic Converter
Catalytic converters typically consist of a ceramic or metal honeycombed monolith substrate that carries precious metal catalysts.